名稱：填充柱

色譜固定液：5%聚乙二醇
載體：石墨炭黑80-120目

規格：2m*3mm，2m*1/8

型號：5%Carbowax 20M Carbopack B

應用： HJ T33-1999 固定污染源排氣中甲醇的測定氣相色譜法

 適用范圍

1.1 本標準適用于固定污染源有組織排放和無組織排放的甲醇測定。

1.2 以3倍噪音色譜峰高值計算，當色譜進樣量為1.0 ml時，方法的檢出限為2 mg/m³；定量測定的濃度范圍為5.0-10⁴ mg/m³。

2 方法原理
      載氣攜帶含有甲醇(CH₃OH）的試樣通過裝有固定相的色譜柱，流出色譜柱的甲醇由氫火焰離子化檢測器(FID)測定。以標準樣品色譜峰的保留時間進行定性，以峰高（或峰面積）定量。

浩瀚色譜（山東）應用技術開發有限公司首先使用純水為吸收液,吸收空氣中的甲醇,再采用頂空氣相色譜法分析吸收液中甲醇濃度,由此建立了自動頂空5%Carbowax 20M Carbopack B填充柱氣相色譜法測定空氣和廢氣中甲醇的方法,并對自動頂空進樣條件進行了優化。結果表明,當采樣體積為24 L、吸收液體積5 mL時,該方法的低檢出濃度為0.1 mg/m3,相對標準偏差為2.1%～5.3%,加標回收率為95%～108%。該法操作簡單,具有較好的靈敏度和的準確度,自動化程度高,可連續完成樣品的前處理、樣品進樣和色譜分析。


頂空氣相色譜測定大氣污染物中甲醇含量  測試譜圖：


Determination of Methanol in Air Pollutants by Headspace Gas Chromatography
Determination of Methanol in Air Pollutants by Headspace Gas Chromatography Details:

Name: Packed Column

Chromatographic fixative: 5% polyethylene glycol
Carrier: graphite carbon black 80-120 mesh

Specifications: 2m*3mm, 2m*1/8

Model: 5%Carbowax 20M Carbopack B

Application: HJ T33-1999 Determination of methanol in exhaust gas from stationary pollution sources by gas chromatography



 Scope of application

1.1 This standard is applicable to the determination of methanol in organized and unorganized emissions from stationary pollution sources.

1.2 Calculated by 3 times the noise chromatographic peak height, when the chromatographic injection volume is 1.0 ml, the detection limit of the method is 2 mg/m3; the concentration range of quantitative determination is 5.0-104 mg/m3.

2 Principles of the method
      The carrier gas carries a sample containing methanol (CH3OH) through a chromatographic column equipped with a stationary phase, and the methanol flowing out of the chromatographic column is detected by a hydrogen flame ionization detector (FID). Qualitative by the retention time of the standard sample chromatographic peak, quantitative by peak height (or peak area).

Haohan Chromatography (Shandong) Application Technology Development Co., Ltd. first used pure water as the absorption liquid to absorb methanol in the air, and then used headspace gas chromatography to analyze the methanol concentration in the absorption liquid, thus establishing an automatic headspace 5% Carbowax 20M Carbopack B. A method for the determination of methanol in air and waste gas by packed-column gas chromatography, and the automatic headspace injection conditions were optimized. The results show that when the sampling volume is 24 L and the absorption liquid volume is 5 mL, the minimum detection concentration of this method is 0.1 mg/m3, the relative standard deviation is 2.1%-5.3%, and the recovery rate of standard addition is 95%-108% . The method is simple to operate, has good sensitivity and reliable accuracy, and has a high degree of automation. It can continuously complete sample pretreatment, sample injection and chromatographic analysis.


Determination of methanol content in air pollutants by headspace gas chromatography Test spectrum: